Proceedings of International Conference on Applied Innovation in IT
2023/11/30, Volume 11, Issue 2, pp.137-142

Isroil Yuldoshev, Shahzod Rahmatillaev, Sanjar Shoguchkarov and Uygun Xolov


Hydraulic and Thermal Engineering Calculation in the Laminar Mode of Operation of a Photoelectric Thermal Battary


Abstract: Efficient conversion of solar energy into electrical and thermal energy has become a major goal of researchers around the world. In this regard, the authors have developed photovoltaic thermal installations to efficiently convert solar energy into electricity and heat. This article briefly analyses the development of a photovoltaic thermal system for efficient cooling of the photovoltaic part with various methods and coolants. A photovoltaic thermal battery (PTB) with a cooling system based on multichannel polycarbonate has been developed. The dimensions of the cellular polycarbonate channels are 7 x 12 mm2. Water flows horizontally through more than 200 channels in parallel streams. The thickness of the cellular polycarbonate sheet is 4 mm. The PTB cooling system is a structure consisting of a sheet of cellular polycarbonate and channel openings, which are attached to two perpendicularly located polypropylene tubes using transparent silicone sealant. This design of the cooling system (absorber) has less weight and a lower cost compared to traditional metal structures, and the cellular polycarbonate sheet in the PTB is protected from direct exposure to ultraviolet radiation emitted by the sun. The model of a combined PTB installation based on a "photovoltaic battery and heat converter" (PVB-TC) was implemented using COMSOL Multiphysics 5.6. Hydraulic and thermal calculations were carried out in laminar mode, and PTB parameters were determined: water temperature at the outlet of the absorber PTB , water pressure at the inlet of the absorber , and water flow G at the corresponding water velocities W=0.1 m/s, 0.2 m/s, and 0.3 m/s, taking into account three values of ambient temperature - 25 °C, 35 °C, and 45 °C. The modelling process took into account the use of concentrated solar radiation in a combined PEP-TEP installation using weakly concentrating reflectors.

Keywords: Hydrodynamic Calculation, COMSOL Multiphysics 5.6, Photovoltaic Thermal Battery, Cooling Methods, Model, Thermal Analysis, Water Velocity, Water Flow, Water Temperature, Pressure, Environment.

DOI: 10.25673/113004

Download: PDF

References:

  1. R. Lamba and S.C. Kaushik, "Modeling and performance analysis of a concentrated photovoltaic-thermoelectric hybrid power generation system," Energy Conversion and Management, vol. 115, pp. 288-298, 2016, [Online]. Available: https://doi.org/10.1016/j.enconman.2016.02.061.
  2. I. Jurayev, I. Yuldoshev, and Z. Jurayeva, "Effects of Temperature on the Efficiency of Photovoltaic Modules," Proceedings of International Conference on Applied Innovation in IT, Volume 11, Issue 1, pp. 199-206, doi:10.25673/101938.
  3. V.M. Evdokimov and V.A. Mayorov, "A study of limiting energy and temperature characteristics of photovoltaic solar radiation converters," Applied Solar Energy, vol. 53, no. 1, pp. 1-9, 2017, doi:10.3103/S0003701X17010042.
  4. A. Royne, C.J. Dey, and D.R. Mills, "Cooling of photovoltaic cells under concentrated illumination: a critical review," Solar Energy Materials and Solar Cells, vol. 86, pp. 451-483, 2005, [Online]. Available: http://dx.doi.org/10.1016/j.solmat.2004.09.003.
  5. A. Fudholi, K. Sopian, M.H. Yazdi, M.H. Ruslan, A. Ibrahim, and H.A. Kazem, "Performance analysis of photovoltaic thermal (PVT) water collectors," Energy Conversion and Management, no:78, pp. 641-651, 2014, [Online]. Available: http://dx.doi.org/10.1016/j.enconman.2013.11.017.
  6. A. Ibrahim, A. Fudholi, K. Sopian, M.Y. Othman, and M.H. Ruslan, "Efficiencies and improvement potential of building integrated photovoltaic thermal (BIPVT) system," Energy Conversion and Management, no.77, pp. 527-534, 2014, [Online]. Available: http://dx.doi.org/10.1016/j.enconman.2013.10.033.
  7. A. Ibrahim, M.Y. Othman, M.H. Ruslan, S. Mat, and K. Sopian, "Recent advances in flat plate photovoltaic/thermal (PV/T) solar collectors," Renewable and Sustainable Energy Reviews, vol. 15(1), pp. 352-365, 2011, [Online]. Available: http://dx.doi.org/10.1016/j.rser.2010.09.024.
  8. S.A. Hamid, M.Y. Othman, K. Sopian, and S.H. Zaidi, "An overview of photovoltaic thermal combination (PV/T combi) technology," Renewable and Sustainable Energy Reviews, no.38, pp. 212-222, 2014, [Online]. Available: http://dx.doi.org/10.1016/j.rser.2014.05.083.
  9. R. Kumar and M.A. Rosen, "A critical review of photovoltaic-thermal solar collectors for air heating," Applied Energy, vol.88(11), pp. 603-614, 2011, [Online]. Available: http://dx.doi.org/10.1016/j.apenergy.2011.04.044.
  10. T.T. Chow, W. He, A.L.S. Chan, K.F. Fong, Z. Lin, and J. Ji, "Computer modeling and experimental validation of a building-integrated photovoltaic and water heating system," Applied Thermal Engineering, vol.28(11-12), pp. 1356-1364, 2008, [Online]. Available: http://dx.doi.org/10.1016/j.applthermaleng.2007.10.007.
  11. A. Hazi, G. Hazi, R. Grigore, and S. Vernica, "Opportunity to use PVT systems for water heating in industry," Applied Thermal Engineering, vol.63(1), pp. 151-157, 2014, [Online]. Available: http://dx.doi.org/10.1016/j.applthermaleng.2013.11.010.
  12. T.T. Chow, "A review on photovoltaic/thermal hybrid solar technology," Applied Energy, vol. 87, pp. 365-379, 2009, [Online]. Available: http://dx.doi.org/10.1016/j.apenergy.2009.06.037.
  13. M.A. Hasan and K. Sumathy, "Photovoltaic thermal module concepts and their performance analysis: a review," Renewable and Sustainable Energy Reviews, vol. 14, pp. 1845-1859, 2010, [Online]. Available: http://dx.doi.org/10.1016/j.rser.2010.03.011.
  14. X. Zhang, X. Zhao, S. Smith, J. Xu, and X. Yu, "Review of R&D progress and practical application of the solar photovoltaic/thermal (PV/T) technologies," Renewable and Sustainable Energy Reviews, vol.16, pp. 599-617, 2012, [Online]. Available: http://dx.doi.org/10.1016/j.rser.2011.08.026.
  15. M.Y. Othman, A. Ibrahim, G.L. Jin, M.H. Ruslan, and K. Sopian, "Photovoltaic-thermal (PV/T) technology-the future energy technology," Renewable Energy, vol.49, pp. 171-174, http://dx.doi.org/10.1016/j.renene.2012.01.038.
  16. A. Fudholi, M. Zohri, G.L. Jin, A. Ibrahim, C.H. Yen, M.Y. Othman, and et al., "Energy and exergy analyses of photovoltaic thermal collector with ∇-groove," Solar Energy, vol.159, pp. 742-750, 2018, [Online]. Available: http://dx.doi.org/10.1016/j.solener.2017.11.056.
  17. R.R. Avezov, J.S. Akhatov, and N.R. Avezova, "A review on photovoltaic-thermal (PV-T) air and water collectors," Applied Solar Energy, vol. 47, pp. 169-183, 2011, [Online]. Available: https://doi.org/10.3103/S0003701X11030042.
  18. J.K. Tonui and Y. Tripanagnostopoulos, "Air-cooled PV/T solar collectors with low-cost performance improvements," Solar Energy, vol.81, pp. 498-511, 2007, doi:10.1016/j.solener.2006.08.002.
  19. A. Shahsavar and M. Ameri, "Experimental investigation and modeling of a direct-coupled PV/T air collector," Solar Energy, vol. 84, no. 11, pp. 1938-1958, 2010, doi:10.1016/j.solener.2010.07.010.
  20. F. Sarhaddi, S. Farahat, H. Ajam, and A. Behzadmehr, "Exergetic performance assessment of a solar photovoltaic thermal (PV/T) air collector," Energy and Buildings, vol. 42, pp. 2184-2199, 2010, [Online]. Available: https://doi.org/10.1016/j.enbuild.2010.07.011.
  21. A.S. Joshi and A. Tiwari, "Energy and exergy efficiencies of a hybrid photovoltaic-thermal (PV/T) air collector," Renewable Energy, vol.32, pp. 2223-2241, 2007, [Online]. Available: https://doi.org/10.1016/j.renene.2006.11.013.
  22. A. Bulusu and D.G. Walker, "Review of electronic transport models for thermoelectric materials," Superlattices and Microstructures, vol. 44, pp. 1-36, 2008, [Online]. Available: https://doi.org/10.1016/j.spmi.2008.02.008.
  23. M. Mirzabaev, S.L. Lutpullaev, R.R. Avezov, M.N. Tursunov, A.M. Mirzabaev, and et al., "Patent for utility model “Photoheat converter” No. FAP 00496," Official Bulletin of the State Patent Office of the Republic of Uzbekistan, No. 10(102), pp. 54-55, 2009, [Online]. Available: https://nsp.gov.uz/static/uploads/blutten72c1cd7d-ff60-4dec-84b2-b1b483416e26.pdf.
  24. A.G. Kamilov, R.A. Muminov, and M.N. Tursunov, "Evaluation of solar element and collector system efficiency under hot climate conditions," Applied Solar Energy, vol.44, no. 2, pp. 90-92, 2008, https://www.scopus.com/record/display.uri?eid=2-s2.0-59949089631&origin=resultslist.
  25. R. Santbergen, C.M. Rindt, H.A. Zondag, and R.Ch. Zolingen, "Detailed analysis of the energy yield of systems with covered sheet-and-tube PV-T collectors," Solar Energy, vol. 84, pp. 867-878, 2010, doi:10.1016/j.solener.2010.02.014.
  26. G. Dosymbetova, S. Mekhilef, A. Saymbetov, M. Nurgaliyev, A. Kapparova, and et al, "Modeling and Simulation of Silicon Solar Cells under Low Concentration Conditions," Energies, vol.15,9404,2022, [Online]. Available: https://doi.org/10.3390/en15249404.
  27. S.K. Shoguchkarov, A.S. Halimov, I.A. Yuldoshev, and T.R. Jamolov, "Verification of a Mathematical Model for a Photovoltaic Thermal-Thermoelectric Generator Unit Using Concentrated Solar Radiation," Applied Solar Energy, vol.57, no. 5, pp. 384-390, 2021, doi: 10.3103/S0003701X21050121.
  28. S.A. Kalogirou, "Use of TRNSYS for modeling and simulation of a hybrid PV-thermal solar system for Cyprus," Renewable Energy, vol. 23, no. 2, pp. 247-260, 2001, [Online]. Available: https://www.researchgate.net/profile/Nikhil_Narale/post/I-want-to-model-a-CCHP-system-with-PV-Thermal-cell-as-its-prime-mover-in-trnsys-I-am-new-in-this-program-Can-anybody-help/attachment/5d627830cfe4a7968dc4167c/AS%3A795755832938496%401566734383950/download/2.pdf.
  29. S.A. Kalogirou and Y. Tripanagnostopoulos, "Hybrid PV/T solar systems for domestic hot water and electricity production," Energy Conversion and Management, vol.47, no. 18-19, pp. 3368-3382, 2006, [Online]. Available:https://doi.org/10.1016/j.enconman.2006.01.012.
  30. B. Sandnes and J. Rekstad, "A photovoltaic/thermal (PV/T) collector with a polymer absorber plate: experimental study and analytic model," Solar Energy, vol. 72, no. 1, pp. 63-73, 2002, [Online]. Available: http://dx.doi.org/10.1016/S0038-092X(01)00091-3.
  31. B. Hallmark, C.H. Hornung, D. Broady, C. Price-Kuehne, and M.R. Mackley, "The application of plastic microcapillary films for fast transient micro-heat exchange," International Journal of Heat and Mass Transfer, vol. 51, pp. 5344-5358, 2008, [Online]. Available: http://dx.doi.org/10.1016/j.ijheatmasstransfer.2008.01.036.
  32. H. Haloui, K. Touafek, M. Zaabat, A. Khelifa, "Comparative Study of the Hybrid Solar Thermal Photovoltaic Collectors Based on Thin Films Solar Cells in South of Algeria," Research and Review in Electrochemistry, vol. 8( 2), October, 2017, ISSN: 0974-7540.
  33. V. Tomar, G.N. Tiwari, T.S. Bhatti, and B. Norton, “Thermal modeling and experimental evaluation of five different photovoltaic modules integrated on prototype test cells with and without water flow,” Energy Conversion and Management, vol.165, pp. 219-235, 2018, [Online]. Available: https://doi.org/10.1016/j.enconman.2018.03.039.

    HOME

       - Call for Papers
       - For authors
       - Important Dates
       - Conference Committee
       - Editorial Board
       - Reviewers
       - Last Proceedings


    PROCEEDINGS

       - Volume 12, Issue 1 (ICAIIT 2024)        - Volume 11, Issue 2 (ICAIIT 2023)
       - Volume 11, Issue 1 (ICAIIT 2023)
       - Volume 10, Issue 1 (ICAIIT 2022)
       - Volume 9, Issue 1 (ICAIIT 2021)
       - Volume 8, Issue 1 (ICAIIT 2020)
       - Volume 7, Issue 1 (ICAIIT 2019)
       - Volume 7, Issue 2 (ICAIIT 2019)
       - Volume 6, Issue 1 (ICAIIT 2018)
       - Volume 5, Issue 1 (ICAIIT 2017)
       - Volume 4, Issue 1 (ICAIIT 2016)
       - Volume 3, Issue 1 (ICAIIT 2015)
       - Volume 2, Issue 1 (ICAIIT 2014)
       - Volume 1, Issue 1 (ICAIIT 2013)


    PAST CONFERENCES

       ICAIIT 2024
         - Photos
         - Reports

       ICAIIT 2023
         - Photos
         - Reports

       ICAIIT 2021
         - Photos
         - Reports

       ICAIIT 2020
         - Photos
         - Reports

       ICAIIT 2019
         - Photos
         - Reports

       ICAIIT 2018
         - Photos
         - Reports

    ETHICS IN PUBLICATIONS

    ACCOMODATION

    CONTACT US

 

DOI: http://dx.doi.org/10.25673/115729


        

         Proceedings of the International Conference on Applied Innovations in IT by Anhalt University of Applied Sciences is licensed under CC BY-SA 4.0


                                                   This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License


           ISSN 2199-8876
           Publisher: Anhalt University of Applied Sciences

        site traffic counter

Creative Commons License
Except where otherwise noted, all works and proceedings on this site is licensed under Creative Commons Attribution-ShareAlike 4.0 International License.